Bauer Compressors B-RFID RF ID Reader in Air Fill Station User Manual Part 3

Bauer Compressors, Inc RF ID Reader in Air Fill Station Users Manual Part 3

Users Manual Part 3

MNL-0021Item Qty Part No. Description NotesFigure 3-49
UNICUS 4i3.3.2 Trouble shootingTrouble Cause Remedy
MNL-0021CHAPTER 4: PURIFICATION SYSTEM 4.1 Introduction 4.1.1 General Purification System Procedures4.1.2 Chamber Safety BoreWARNING
UNICUS 4i4.1.3 Manual Condensate Drainage4.1.4 Model, Serial Number and Part Number Identification4.1.4.1Figure 4-1 Figure 4-2Figure 4-3SafetyVent(no leak)Cartridge InstalledcorrectlySafetyVent(leaking)No Cartridge Installedor Installed incorrectlyC ar tridge In sta lledC or rectl y No Car tridge o r Instal ledIncorrectl ySafety Ve ntSafety VentCARTRIDGE FORCARTRIDGE NO.LBL-0044CARTRIDGE TO BEINSTALLED132 8 Azale a Ga rden R oad - Norfolk Virginia 23502-1 944Phone : (757) 855-6006 Fa x: (757) 855-82 24MODEL NO .MAX. PRE SS UREAIR PROC ESSEDO-RINGBACK- UP RIN Gpsigcu. ft.LBL-0191PUR IFICATIONSYSTEM
MNL-00214.1.4.24.1.4.34.1.5 Purification System ConfigurationsPurification System Number and Type of Cartridges Processing CapacityDryer Purification Securus® cubic ft (ft)3
UNICUS 4i4.1.6 Industrial Purification System Configurations4.1.7 Cartridge Operating LifePurification System Number and Type of Cartridges Processing CapacityDryer Purification Securus®cubic ft (ft)3
MNL-00214.1.7.14.1.7.2
UNICUS 4iFigure 4-4Figure 4-510/19/04 8 92°F (33 °C)0.5 16.00 16.0011/01/04 4 45°F (7.2 °C)2.25 1.78 17.78Op hrsCorr. factor Total hrs+Today hr s
MNL-00214.1.7.3Date Operating hoursAmbient temp. + 18°Fduring compressionCorrection factorAdjusted cartridge hoursToday Total
UNICUS 4i4.2 1P5S Securus II Purification System4.2.1 P5S Securus II Purification System Major ComponentsFigure 4-6
MNL-00214.3 Component Description4.3.1 Oil and Water Separator4.3.2 Chamber4.3.3 Cartridge4.3.3.1WARNINGFigure 4-7
UNICUS 4i4.3.3.24.3.4 Condensate Drain Valve4.3.5 Check Valves4.3.6 Bleed Valve4.3.7 Pressure Maintaining Valve4.3.8 Safety Valve4.3.9 Securus II Electronic Moisture Monitor System4.3.9.14.3.9.2Protective CapPurificationCartridge
MNL-00214.4 Maintenance4.4.1 Oil and Water Separator
UNICUS 4iFigure 4-8 Figure 4-91234
MNL-00214.4.1.14.4.2 Cartridge ReplacementFigure 4-10 NOTICEFigure 4-11
UNICUS 4i4.4.2.1 NOTICE
MNL-00214.5 Replacement Parts List Item Qty Part No. Description Notes1 gauge stock, 2nd is optionalFigure 4-12
UNICUS 4iItem Qty Part No. Description NotesFigure 4-13
MNL-0021Item Qty Part No. Description NotesFigure 4-141234455678
UNICUS 4iItem Qty Part No. Description NotesFigure 4-1512345329678101112131415161718
MNL-0021Figure 4-15 (cont.)Item Qty Part No. Description Notes
UNICUS 4iCHAPTER 5: COMPRESSOR DRIVE; UNICUS 4I5.1 Vertical Compressor Drive5.2 Maintenance of the V-belt and Sheaves5.2.1 Check The Sheaves. Figure 5-1
MNL-00215.2.2 Check the V-belt5.2.3 Replacing the Belt5.2.4 Replacing the SheaveFigure 5-2 Figure 5-3 NOTICE
UNICUS 4i5.3 Replacement Part ListItem Qty Part No. Description NotesUNICUS 4i - 25Figure 5-4
MNL-0021CHAPTER 6: ELECTRICAL PANEL, ASY-11916.1 Overview, 6.2 Electrical Panel6.2.1 Wiring Diagram6.2.2 Electrical Panel Interior AccessFigure 6-1
UNICUS 4i6.3 AC Power Requirements6.4 Electrical Panel Components6.4.1 Programmable Logic Controller (PLC)Figure 6-2Figure 6-3
MNL-00216.4.1.16.4.1.2Figure 6-4
UNICUS 4i6.4.1.36.4.2 Hour Meter6.4.3 Motor Starter.Figure 6-5
MNL-00216.4.4 Overload Relay6.4.5 Power SupplyFigure 6-6 Figure 6-7Figure 6-8
UNICUS 4i6.5 Alarms6.5.1 Final Separator Warning6.5.2 Compressor High TemperatureTable 6-1: Maximum Compressor Pressure Warning Shutdown WARNINGFigure 6-9 Figure 6-10
MNL-00216.5.3 Compressor Low Oil PressureOIL PRESS TD
UNICUS 4i6.6 Replacement Parts ListItem Qty Part No. Description NotesFigure 6-11
MNL-0021Figure 6-11 (cont.)Item Qty Part No. Description Notes
UNICUS 4iCHAPTER 7: RFID OPTION 7.1 Description7.2 Components NOTICEFigure 7-1
MNL-00217.3 Functions7.3.1 Assigning the Cylinder7.3.2 Filling the Cylinder with RFID OptionFigure 7-2
UNICUS 4i7.4 Replacement Parts ListItem Qty Part No. Description NotesFigure 7-3
MNL-0021CHAPTER 8: ENMET GAS MONITORS8.1 Description8.2 OperationSen-sor Figure 8-1
UNICUS 4i8.3 CalibrationFigure 8-2Figure 8-3
MNL-00218.4 Sensor Replacement
UNICUS 4i8.5 Replacement PartsItem Qty Part No. Description NotesFigure 8-4
1 2345986107
UNICUS 4iItem Qty Part No. Description NotesFigure 8-5
MNL-0021Figure 8-5 (cont.)Item Qty Part No. Description Notes
UNICUS 4iItem Qty Part No. Description Notes*****Figure 8-6
MNL-0021Item Qty Part No. Description NotesFigure 8-7

Navigation menu